Hydraulic Filter / Hydraulic Oil Filter for auto

Filter auto parts: Hydraulic Filter / Hydraulic Oil Filter

How to detect malfunction of the hydraulic power steering filter

The state of the component may be diagnosed visually. First, check that the housing is not deformed, and how much the filter element is clogged. If the filter has turned yellow, it is a symptom of clogging of over 75%. The value below this one is considered acceptable. Critical level of clogging (90% or more) is indicated by red color. More accurate results are obtained by electronic diagnostics. During diagnostics, information about the extent of filter clogging and damage is transmitted from the indicator to the on-board computer.

You may notice that the hydraulic power steering filter needs diagnostics by the following symptoms:

  • the vehicle moves unevenly;
  • unusual noises are heard;
  • the working fluid is supplied with difficulty;
  • lacquer-like residue, component clogging;
  • defects in the pump due to cavitation;
  • oil gets dirty in a short time;
  • hydraulic resistance has increased;
  • insufficient or excessive degree of purification.

The reasons of hydraulic power steering filter malfunction

Hydraulic Oil Filter is a consumable item that is to be replaced over time. Typically, its service life is determined by the manufacturer. However, it may fail sooner in some cases. This usually happens when poor quality, improper or contaminated fluid is used.

Using oil that does not meet the technical requirements of the vehicle may result in damaging seals, with further clogging of the filtering element with the products of seals wear. Premature abrasion of the components of the system may be the result of insufficient amount of the hydraulic fluid. Loss of pipeline tightness and ingress of water inside the power steering unit result in fluid oxidation and accumulation of sludge, thus impairing the filter throughput. The use of poor quality oil may also lead to similar consequences. To avoid heating of the liquid whereby its properties change and the wear of the system components increases, it is not recommended to keep the steering wheel in the extreme position for more than about five seconds.

Hydraulic Oil Filter repair and replacement

During repair, the working fluid and the filtering element are replaced. Reusable hydraulic filters allow for replacement of the filtering element for up to 15 times. At the end of the component's service life, it is replaced with a new one. The working fluid is replaced with the use of tubes and a syringe. Before installation of the new component, rinse the gasket and a spring bracket that hold the filter in place. If the old gasket is worn out, use a new one. Then remove metal chips from the magnet and pour the liquid.

Popular Hydraulic Filter / Hydraulic Oil Filter manufacturers
Original Hydraulic Filter / Hydraulic Oil Filter from MAPCO producer Original Hydraulic Filter / Hydraulic Oil Filter from MEYLE producer Original Hydraulic Filter / Hydraulic Oil Filter from MANN-FILTER producer Original Hydraulic Filter / Hydraulic Oil Filter from FEBI BILSTEIN producer Original Hydraulic Filter / Hydraulic Oil Filter from SWAG producer Original Hydraulic Filter / Hydraulic Oil Filter from JP GROUP producer Original Hydraulic Filter / Hydraulic Oil Filter from MAHLE ORIGINAL producer Original Hydraulic Filter / Hydraulic Oil Filter from DONALDSON producer
Original Hydraulic Filter / Hydraulic Oil Filter from ERA Benelux producer Original Hydraulic Filter / Hydraulic Oil Filter from BOSCH producer Original Hydraulic Filter / Hydraulic Oil Filter from KNECHT producer Original Hydraulic Filter / Hydraulic Oil Filter from HENGST FILTER producer Original Hydraulic Filter / Hydraulic Oil Filter from AUGER producer Original Hydraulic Filter / Hydraulic Oil Filter from DT producer Original Hydraulic Filter / Hydraulic Oil Filter from SogefiPro producer Original Hydraulic Filter / Hydraulic Oil Filter from MAGNETI MARELLI producer
Top quality parts Hydraulic Filter / Hydraulic Oil Filter for your car
Buy DT Hydraulic Filter, steering system 1.19150 for car at low price £ 5,03
-12%
£ 5,03
£ 5,72
incl. 20% VAT, Shipping
x Hydraulic Filter, steering system | DT 1.19150
Parts Details
  • Weight [g]: 167
  • Filter type: Filter Insert
  • Inner diameter [mm]: 18
  • Outer diameter [mm]: 60
  • Height [mm]: 100
In stock Details
Buy MANN-FILTER Hydraulic Filter, steering system HD 45 for car at low price £ 16,68
-12%
£ 16,68
£ 18,96
incl. 20% VAT, Shipping
x Hydraulic Filter, steering system | MANN-FILTER HD 45
Parts Details
  • Outer diameter [mm]: 35
  • Inner diameter [mm]: 12,2
  • Height [mm]: 94
In stock Details
Buy MAHLE ORIGINAL Hydraulic Filter, steering system HX 44 for car at low price £ 5,24
-26%
£ 5,24
£ 7,00
incl. 20% VAT, Shipping
x Hydraulic Filter, steering system | MAHLE ORIGINAL HX 44
Parts Details
  • Height 1 [mm]: 23,0
  • Height [mm]: 26,0
  • Diameter [mm]: 80,6
  • Outer diameter 1 [mm]: 78,0
  • Inner diameter 1 [mm]: 35,0
In stock Details
Buy MAHLE ORIGINAL Hydraulic Filter, steering system HX 15 for car at low price £ 5,24
-12%
£ 5,24
£ 5,96
incl. 20% VAT, Shipping
x Hydraulic Filter, steering system | MAHLE ORIGINAL HX 15
Parts Details
  • Filter type: Filter Insert
  • Height 1 [mm]: 101,0
  • Diameter [mm]: 59,0
  • Outer diameter 1 [mm]: 59,0
  • Seal Diameter [mm]: 17,8
In stock Details
Buy FILTRON Hydraulic Filter, steering system OM611 for car at low price £ 5,24
-12%
£ 5,24
£ 5,96
incl. 20% VAT, Shipping
x Hydraulic Filter, steering system | FILTRON OM611
Parts Details
  • Shape: Round
  • Height [mm]: 110
  • Diameter [mm]: 82
  • Inner diameter 1 [mm]: 13,5
  • Inner diameter 2 [mm]: 13,5
In stock Details
Buy ERA Benelux Hydraulic Filter, steering system HF002 for car at low price £ 18,44
-12%
£ 18,44
£ 20,96
incl. 20% VAT, Shipping
x Hydraulic Filter, steering system | ERA Benelux HF002
Parts Details
  • Diameter [in]: 1/2"
In stock Details
Buy MANN-FILTER Hydraulic Filter, steering system H 601/6 for car at low price £ 8,76
-12%
£ 8,76
£ 9,96
incl. 20% VAT, Shipping
x Hydraulic Filter, steering system | MANN-FILTER H 601/6
Parts Details
  • Outer diameter [mm]: 59
  • Inner diameter [mm]: 16
  • Inner diameter 1 [mm]: 16
  • Height [mm]: 107
In stock Details
Buy MANN-FILTER Hydraulic Filter, steering system H 85 for car at low price £ 10,52
-12%
£ 10,52
£ 11,96
incl. 20% VAT, Shipping
x Hydraulic Filter, steering system | MANN-FILTER H 85
Parts Details
  • Outer diameter [mm]: 81
  • Inner diameter [mm]: 7
  • Inner diameter 1 [mm]: 35
  • Outer diameter 1 [mm]: 78
  • Height [mm]: 26
In stock Details
  • Contacts
  • TOS
  • Privacy Policy
  • Company
  • Payment
  • Shipping
  • Return of goods
  • Replacement